Friday, May 20, 2011

CUB CADET LTX 1040 will not start and cable adjustment?

The Cub Cadet LTX 1040 is a small riding mower that comes standard with a 19-hp single-cylinder Kohler gasoline engine and a 42-inch-wide mower deck that contains two blades. The blades can be sharpened, but a damaged or bent blade may cause the mower deck to run off-balance.


To remove deck enlargement cable and install follow this procedure:---
  • Turn off the mower engagement button on the dashboard. Set the parking brake. Lower the mower deck to its lowest setting by moving the adjustment lever on the right fender to its lowest notch.

  • Locate the mower clutch pulley under the front of the mower. Remove the retaining nuts from the belt guard with a socket and ratchet wrench, then remove the guard. Slide the mower drive belt off the clutch pulley.

  • Locate the deck retaining pin on the left side of the mower deck. Pull out on the spring-loaded pin to release the deck from the mounting bracket. Repeat for the right side of the deck. Raise the deck adjustment lever on the right fender to its highest notch.

  • Pull out the retaining pin on the deck engagement cable at the rear of the mower deck. Remove the retaining pin from the stabilizer rod at the front of the deck, then slide the rod out of its mounting hole in the deck.

    Remove the cotter pin holding the deck engage cable in place. The cotter pin is a paper-clip shaped piece of metal used for fastening rods and clamps. The deck engage cable is a heavy cable that runs from the deck height controls on the front of the tractor underneath and to the cutting deck. The cotter pin can be removed with pliers. Remove the cable and the spring from the deck idler bracket.


    To see the cub cadet diagram, see the fig below:--


    1Cub Cadet 954-0266A
    Drive Belt
    Your price: $30.53
    0 of these in your cart
    Qty:
    2Cub Cadet 954-04167
    Timing Belt
    Your price: $64.57
    0 of these in your cart
    Qty:
    3Cub Cadet 710-1325
    Hex Washer Screw, 1.4-20 x 1.625
    Your price: $2.67
    0 of these in your cart
    Qty:
    4Cub Cadet 750-04456
    Spacer, .260 x .372 x 1.420
    Your price: $4.18
    0 of these in your cart
    Qty:
    5Cub Cadet 932-0428A
    Extension Spring, .50 x 4.35
    ((PTO Disengagement & Brake...)
    Your price: $5.58
    0 of these in your cart
    Qty:
    6Cub Cadet 712-04065
    Flange Lock Nut, 3.8-16
    Your price: $2.51
    0 of these in your cart
    Qty:
    7Cub Cadet 756-04129B
    Idler Pulley
    Your price: $20.48
    0 of these in your cart
    Qty:
    8Cub Cadet 936-3004
    Flat Washer, .406 x .875 x .105
    Your price: $3.16
    0 of these in your cart
    Qty:
    9Cub Cadet 750-0807
    Spacer, .385 x .625 x .700
    Your price: $4.16
    0 of these in your cart
    Qty:
    10Cub Cadet 738-04162A
    Shoulder Spacer, .8840 x .190
    Your price: $12.62
    0 of these in your cart
    Qty:
    11Cub Cadet 983-04524
    Brake Assembly
    (For PTO Engagement & Brake...)
    Your price: $24.48
    0 of these in your cart
    Qty:
    12Cub Cadet 710-04484
    Hex Washer Screw, 5.16-18 x .750
    Your price: $2.80
    0 of these in your cart
    Qty:
    13Cub Cadet 783-06176-0637
    Idler Brace Bracket
    Your price: $10.73
    0 of these in your cart
    Qty:
    14Cub Cadet 710-0347
    Hex Screw, 3.8-16 x 1.75
    Your price: $3.04
    0 of these in your cart
    Qty:
    15Cub Cadet 712-0266A
    Jam Lock Nut, 3.8-16
    Your price: $2.64
    0 of these in your cart
    Qty:
    16Cub Cadet 936-0300
    Flat Washer, .406 x .875 x .059
    Your price: $3.04
    0 of these in your cart
    Qty:
    17Cub Cadet 756-04280
    Idler Pulley
    Your price: $19.93
    0 of these in your cart
    Qty:
    18Cub Cadet 712-0229
    Push Nut, 3.8
    Your price: $2.58
    0 of these in your cart
    Qty:
    19Cub Cadet 750-04446
    Spacer, 3.8 x .68 x 1.46
    Your price: $4.18
    0 of these in your cart
    Qty:
    20Cub Cadet 783-05802 (replaces 783-05802-0637)
    Tension Bracket
    Your price: $13.60
    0 of these in your cart
    Qty:
    21Cub Cadet 710-0520
    Hex Screw, 3.8-16 x 1.50
    Your price: $3.04
    0 of these in your cart
    Qty:
    22Cub Cadet 710-1325
    Hex Washer, 1.4-20 x 1.625
    Your price: $2.67
    0 of these in your cart
    Qty:
    23Cub Cadet 750-0566A
    Spacer, .260 x .375 x 1.030
    Your price: $5.54
    0 of these in your cart
    Qty:
    24Cub Cadet 732-0826A
    Extension Spring, .865 x 4.68
    Your price: $7.12
    0 of these in your cart
    Qty:
    25Cub Cadet 737-04003D
    Deck Water Nozzle
    Your price: $14.11
    0 of these in your cart
    Qty:
    26Cub Cadet 710-0528
    Hex Screw, 5.16-18 x 1.25
    Your price: $3.02
    0 of these in your cart
    Qty:
    27Cub Cadet 936-0119
    Lock Washer, 5.16
    Your price: $2.56
    0 of these in your cart
    Qty:
    28Cub Cadet 917-04074
    Deck Adjustment Gear
    Your price: $8.32
    0 of these in your cart
    Qty:
    29Cub Cadet 914-0470
    Cotter Pin, 1.8 x 1.25
    Your price: $2.58
    0 of these in your cart
    Qty:
    30Cub Cadet 932-0306A
    Compression Spring, .531 x 1.75
    Your price: $4.22
    0 of these in your cart
    Qty:
    31Cub Cadet 747-1116
    Deck Handle Rod
    Your price: $7.10
    0 of these in your cart
    Qty:
    32Cub Cadet 738-04316A
    Shoulder Bolt, 5.16-24 x .435 x 1.76
    Your price: $6.28
    0 of these in your cart
    Qty:
    33Cub Cadet 783-05627-063
    Deck Lift Bracket
    Not available
    34Cub Cadet 710-0599
    Hex Washer Screw, 1.4-20 x .500
    Your price: $2.56
    0 of these in your cart
    Qty:
    35Cub Cadet 731-06291A
    Belt Cover
    Your price: $16.75
    0 of these in your cart
    Qty:
    36ACub Cadet 918-04512A
    Spindle Assembly, Drive
    Not available
    36BCub Cadet 918-04516
    Spindle Assembly, Driven
    Not available
    37Cub Cadet 711-1044A
    Belt Guard Pin
    Your price: $5.34
    0 of these in your cart
    Qty:
    38Cub Cadet 783-06262A-0637 (replaces 783-06262-0637)
    Deck Engage Cable Bracket
    Your price: $8.38
    0 of these in your cart
    Qty:
    39Cub Cadet 747-05055
    Belt Keeper Rod
    Your price: $7.76
    0 of these in your cart
    Qty:
    40Cub Cadet 631-04254
    Chute Assembly
    Your price: $28.65
    0 of these in your cart
    Qty:
    41Cub Cadet 734-0973
    Deck Wheel
    Your price: $8.48
    0 of these in your cart
    Qty:
    42Cub Cadet 938-0373
    Shoulder Bolt, 3.8-16 x .496 x 1.525
    Your price: $5.54
    0 of these in your cart
    Qty:
    43Cub Cadet 710-3178
    Carriage Bolt, 3.8-16 x .75
    Your price: $2.62
    0 of these in your cart
    Qty:
    44Cub Cadet 712-04063
    Flange Lock Nut, 5.16 x 18
    Your price: $2.58
    0 of these in your cart
    Qty:
    45Cub Cadet 942-04217
    2-in-1 Blade
    Your price: $28.07
    0 of these in your cart
    Qty:
    46Cub Cadet 712-0417A
    Flange Nut, 5.8-18
    Your price: $4.56
    0 of these in your cart
    Qty:
    47Cub Cadet 710-3130
    Hex Screw, 3.8-16 x 3.25
    Your price: $6.10
    0 of these in your cart
    Qty:
    48Cub Cadet 736-0258
    Flat Washer, .385 x 1.0 x .135
    Your price: $3.04
    0 of these in your cart
    Qty:
    49Cub Cadet 710-3005
    Hex Screw, 3.8-16 x 1.25
    Your price: $2.56
    0 of these in your cart
    Qty:
    50Cub Cadet 938-0785
    Shoulder Spacer, 1.38 x .445 x .36
    Your price: $13.24
    0 of these in your cart
    Qty:
    51Cub Cadet 734-04155
    Deck Wheel
    Your price: $12.56
    0 of these in your cart
    Qty:
    52Cub Cadet 736-0225
    Lock Washer, 5.8
    Your price: $2.62
    0 of these in your cart
    Qty:
    53Cub Cadet 912-0641
    Hex Nut, M16-1.5
    Your price: $3.71
    0 of these in your cart
    Qty:
    54Cub Cadet 983-04492-4021 (replaces 683-04492-4021)
    Deck Assembly
    Your price: $289.68
    0 of these in your cart
    Qty:
    55Cub Cadet 756-04372
    Pulley (Drive Spindle)
    Your price: $19.23
    0 of these in your cart
    Qty:
    56Cub Cadet 750-04724
    Spacer, .792 x 1.060 x 1.860 (Drive Spindle)
    Your price: $6.42
    0 of these in your cart
    Qty:
    57Cub Cadet 913-04040A
    Timing Pulley
    Your price: $36.98
    0 of these in your cart
    Qty:
    58Cub Cadet 787-01520
    Timing Pulley Plate
    Your price: $7.80
    0 of these in your cart
    Qty:
    59Cub Cadet 710-04065
    Screw, 1.4-10 x .625
    Your price: $4.27
    0 of these in your cart
    Qty:
    60Cub Cadet 936-0287
    Flat Washer, .793 x 1.24 x .06
    Your price: $2.62
    0 of these in your cart
    Qty:
    61Cub Cadet 941-0919
    Ball Bearing, .787 x 1.85 x .551
    Your price: $17.91
    0 of these in your cart
    Qty:
    62Cub Cadet 750-04936
    Spacer, .792 x 1.060 x 1.860
    Your price: $4.18
    0 of these in your cart
    Qty:
    63Cub Cadet 937-3000
    Drive Lube Fitting
    Your price: $3.16
    0 of these in your cart
    Qty:
    64Cub Cadet 619-04199
    Spindle Housing
    Your price: $38.48
    0 of these in your cart
    Qty:
    65Cub Cadet 938-04292
    Spindle Shaft (Drive Spindle)
    Your price: $25.98
    0 of these in your cart
    Qty:
    65Cub Cadet 938-04291
    Spindle Shaft (Driven Spindle)
    Your price: $24.55
    0 of these in your cart
    Qty:
    66Cub Cadet 736-0315
    Flat Washer, .760 x 1.50 x .120
    Your price: $4.18
    0 of these in your cart
    Qty:




    For problems like CUB CADET dies when parking brakes released?

    The clutch safety switch will kill the engine when the clutch/brake pedal is released. The deck switch will kill the engine when the blades are engaged. The seat switch will allow the engine to run when the rider isn't present instead of killing the engine when the rider isn't present. They don't usually give you any warning they just quit. You can check the safety switches if you make a jumper wire to use to complete the circuit. This will help determine which switches are bad.

    Make sure your foot is on the clutch pedal. If that is not the problem check the safety switch on the parking brake.

    This is probably a safety switch or wiring issue grounding out the ignition module . The most common is the seat switch, so I suggest checking it first. But in most of the cases this problem is related to seat switch.


    For user manual of your product please click the link below:---
    http://www.cubcadet.com/wcsstore/CubCadetCatalogAssetStore/Attachment/owners%20manuals/residential/2010_LTX1040a.pdf
    -

  • max