Thursday, September 22, 2011

How to remove Heater Core on Toyota Camry ?

Removal & Installation



  1. Before servicing the vehicle, refer to the Precautions Section.
  2. Disconnect the negative battery cable.
    CAUTION
    After disconnecting the negative battery cable, wait for at least 1 1 / 2minutes for the SRS to deplete its energy.

  3. Drain the cooling system into a clean container for reuse.
  4. Remove the air bag module and the steering wheel by performing the following procedure:

    Place the front wheels in the straight-ahead position.
    At both sides of the steering wheel, remove the screw covers.
    Using a Torx socket, loosen the 2 air bag module-to-steering wheel Torx screws until the circumference ring catches on the screw case.
    Carefully, remove the air bag module and disconnect the electrical connector.
    Remove the steering wheel nut.
    Using a steering wheel puller, press the steering wheel from the steering column.

  5. Remove the instrument panel by performing the following procedure:

    Remove the front pillar garnishes and the door scuff plates.
    Remove the hood lock release lever and the cowl side trims.
    Remove the steering column covers and the combination switch.
    Remove the lower finish panel assembly and the instrument panel finish lower left side panel.
    Remove the fuse box bolt and the No. 2 heater-to-register duct.
    Remove the parking brake release lever and the No. 2 undercover.
    Remove the lower No. 2 finish panel.
    If equipped with a column shifter, disconnect the shift control cable from the shift lever housing; then, disconnect the shift control cable from the steering column cable bracket.
    Matchmark the steering column shaft and the control valve shaft.
    Remove the steering column shaft-to-intermediate shaft bolt.
    Remove the steering column-to-instrument panel nuts and remove the steering column assembly.
    Inside the glove compartment, pry out the glove compartment door finish plate.
    Pull out the air bag electrical connector and disconnect it.
    Remove the 3 glove compartment door-to-instrument panel nuts and the door.
    Remove the 4 glove compartment-to-instrument panel screws and the glove compartment; then, disconnect the glove box light connector.
    Remove the passenger-s side air bag module-to-instrument panel 2 bolts and 4 nuts. Carefully, remove the air bag module from the instrument panel.
    Remove the center cluster finish panel and the radio.
    Remove the heater control assembly.
    If equipped with a floor shifter, remove the upper console panel, the rear console box and the front console box.
    If equipped with a column shifter, remove the finish panel.
    Pry out the cluster finish panel.
    Remove the 6 cluster finish panel screws, the cluster finish panel assembly.
    Remove the 4 combination meter screws and the combination meter.
    Disconnect instrument panel electrical connectors.
    Remove the instrument panel-to-chassis nuts/bolts and the remove the instrument panel.

  6. Remove the instrument panels No. 2 brace.
  7. Disconnect the heater hoses from the heater core.
  8. Remove the 2 heater pipes-to-heater core screws and clips; then, disconnect the heater pipes from the heater core.
  9. Remove the heater core O-rings and discard them.
  10. Remove the heater core from the heater housing.

    Click image to see an enlarged view

    Fig. Exploded view of the air bag module, the steering wheel, the floor shift steering column and related components-2002-04 Avalon



    Click image to see an enlarged view

    Fig. Exploded view of the air bag module, the steering wheel, the column shift steering column and related components-2002-04 Avalon



    Click image to see an enlarged view

    Fig. Releasing the air bag module-to-steering wheel screws-2002-04 Avalon



    Click image to see an enlarged view

    Fig. Disconnecting and positioning the air bag module-2002-04 Avalon



    Click image to see an enlarged view

    Fig. Exploded view of the instrument panel and related components-2002-04 Avalon



    Click image to see an enlarged view

    Fig. Exploded view of the wiring harness, ventilation system and related components-2002-04 Avalon



    Click image to see an enlarged view

    Fig. View of the heater/air conditioning assembly and related components-2002-04 Avalon



    Click image to see an enlarged view

    Fig. Exploded view of the evaporator housing, heater housing, heater core and related components-2002-04 Avalon


To install:

  1. Install the heater core to the heater housing.
  2. Install new heater core O-rings.
  3. Install the heater pipes to the heater core; then, the 2 heater pipes-to-heater core screws and clips.
  4. Install the heater hoses to the heater core.
  5. Install the instrument panels No. 2 brace.
  6. Install the instrument panel by performing the following procedure:

    Install the instrument panel and the instrument panel-to-chassis nuts/bolts.
    Install instrument panel electrical connectors.
    Install the combination meter and the 4 combination meter screws.
    Install the cluster finish panel, the 6 cluster finish panel assembly screws.
    Install the cluster finish panel.
    If equipped with a column shifter, install the finish panel.
    If equipped with a floor shifter, install the upper console panel, the rear console box and the front console box.
    Install the heater control assembly.
    Install the center cluster finish panel and the radio.
    Carefully, install the air bag module to the instrument panel; then, install the passenger-s side air bag module-to-instrument panel 2 bolts and 4 nuts.
    Install the glove compartment and the 4 glove compartment-to-instrument panel screws; then, install the glove box light connector.
    Install the glove compartment door and the 3 door-to-instrument panel nuts.
    Connect the air bag electrical connector.
    Inside the glove compartment, install the glove compartment door finish plate.
    Install the steering column assembly and the steering column-to-instrument panel nuts; then, torque the nuts to 19 ft. lbs. (25 Nm).
    Align the matchmarks and install the steering column shaft-to-intermediate shaft bolt.
    If equipped with a column shifter, install the shift control cable to the shift lever housing; then, install the shift control cable to the steering column cable bracket.
    Install the lower No. 2 finish panel.
    Install the parking brake release lever and the No. 2 undercover.
    Install the fuse box bolt and the No. 2 heater-to-register duct.
    Install the lower finish panel assembly and the instrument panel finish lower left side panel.
    Install the steering column covers and the combination switch.
    Install the hood lock release lever and the cowl side trims.
    Install the front pillar garnishes and the door scuff plates.

  7. Install the air bag module and the steering wheel by performing the following procedure:

    Align the matchmarks and install the steering wheel to the steering column.
    Install the steering wheel nut and torque to 26 ft. lbs. (35 Nm).
    Carefully, connect the electrical connector and install the air bag module.
    Using a Torx socket, tighten the 2 air bag module-to-steering wheel Torx screws to 78 inch lbs. (8.8 Nm).
    At both sides of the steering wheel, install the screw covers.

  8. Refill the cooling system.
  9. Install the negative battery cable.
  10. Operate the engine to normal operating temperatures; then, check the climate control operation and check for leaks.

  1. Before servicing the vehicle, refer to the Precautions Section.
  2. Discharge and recover the refrigerant from the air conditioning system.
  3. Drain the cooling system.
  4. Remove or disconnect the following:

    Negative battery cable
    Wiper arm and blade assembly
    Right-side top cowl ventilator louver
    Wiper motor and linkage assembly
    Outside top cowl panel
    Air conditioner lines
    Heater hoses

  5. To remove the instrument panel safety pad, remove or disconnect the following:

    Steering wheel covers
    Horn button
    Steering wheel assembly
    Steering column covers
    Turn signal switch assembly
    Instrument cluster finishing trim
    Instrument panel trim around the steering column
    Instrument panel center panel
    Radio
    Instrument cluster cover
    Gauge cluster assembly
    Accessory cluster assembly
    Instrument panel registers
    Speaker covers
    Front speakers
    Side cowl trim
    Front door scuff plates
    Instrument panel under cover
    Lower finishing panels
    Lower instrument panel airbag assembly
    Shift lever knob
    Shift indicator housing
    Seat heater switch, if equipped
    Center console upper panel

    Click image to see an enlarged view

    Fig. Location of the clips holding the center console-2005-06 Avalon




    Center console
    Lower center instrument panel
    Instrument side panels
    A-pillar trim
    Passenger airbag connector
    Instrument panel safety pad

    Click image to see an enlarged view

    Fig. Location of the instrument panel mounting clips and nuts-2005-06 Avalon


  6. Remove or disconnect the following:

    No. 2 heater duct
    No. 6 heater duct
    Console box duct
    Floor carpet brackets
    Rear air ducts
    No. 1 air duct
    Steering intermediate shaft
    Steering column assembly
    Instrument panel reinforcement

    Click image to see an enlarged view

    Fig. Location of the clamps for the instrument panel reinforcement wiring harness-2005-06 Avalon



    Click image to see an enlarged view

    Fig. Location of the mounting points for the instrument panel reinforcement and exploded view of the ventilation system-2005-06 Avalon




    Blower assembly

  7. Remove or disconnect the following from the blower assembly:

    Air outlet control servomotor
    Air mix control servomotor
    Heater pipe clamps
    Heater core

  8. Installation is the reverse order of removal.
  9. Refill the cooling system to the correct level.
  10. Start the engine and check for leaks.


NOTE
Removal of the heater core requires removal of the entire heater air conditioning assembly.

  1. Before servicing the vehicle, refer to the Precautions Section.
  2. Drain the cooling system into a clean container for reuse.
  3. Disconnect the negative battery cable. Wait 90 seconds before doing any further work while the airbag system de-energizes.
  4. Discharge and recover the air conditioning system refrigerant.
  5. Disconnect A/C suction hose (No. 1) and Liquid pipe (A)
    1. Install SST to piping clamp
    2. Push down SST and release the clamp lock
      WARNING
      Be careful not to deform the tube, when pushing the SST


      NOTE
      Cap the open fittings immediately to prevent system contamination


  6. Remove or disconnect the following:

    Heater core hoses

  7. Disassemble the dash components as follows
    WARNING
    Follow air bag removal procedures



    Lower steering column cover
    Steering wheel
    Instrument cluster finish panel sub-assembly
    Steering column cover
    Headlamp dimmer switch assembly
    Windshield wiper switch assembly
    Combination meter assembly
    Door scuff plates
    LH instrument panel under cover sub-assembly
    Cowl side trim
    Coin box
    LH upper instrument panel sub assembly
    LH lower instrument panel brace
    Air conditioning control assembly

    Click image to see an enlarged view

    Fig. Instrument cluster finish panel clip locations-Camry



    Click image to see an enlarged view

    Fig. Air conditioning control panel clips-Camry



    Click image to see an enlarged view

    Fig. Radio panel clips-Camry

    Instrument panel center cluster finish panel
    Glove box door
    RH lower instrument panel sub-assembly
    Shift lever knob on M/T
    Remove the console panel
    Rear console box
    Cup holder and ashtray
    Upper console panel
    Front console box
    Instrument panel finish plate
    LH & RH front pillar garnish
    Instrument panel speakers
    Passenger air bag connector
    Instrument panel safety pad cap
    Instrument panel safety pad sub-assembly

  8. Remove or disconnect the following:

    Rear air ducts
    Console box duct
    Floor shift parking lock cable assembly
    Windshield wiper relay assembly
    Instrument panel brace assemblies
    Lower instrument finish panel retainer
    Heater to foot ducts
    Steering column assembly
    Instrument panel reinforcements
    Heater blower assembly
    Lower defroster nozzles
    Air conditioning radiator assembly
    Mode damper servo sub-assembly
    Airmix damper servo sub-assembly
    Heater radiator (core) sub-assembly

    Click image to see an enlarged view

    Fig. Instrument panel safety pad fastener locations-Camry



    Click image to see an enlarged view

    Fig. Air conditioning radiator assembly-Camry



To install:

Install or connect the following:

  1. Heater core unit sub assembly

    Heater core into A/C assembly
    Screw and clamp
    Air conditioning radiator assembly
    Lower defroster nozzles
    Heater blower assembly
    Instrument panel reinforcements
    Steering column assembly
    Heater to foot ducts
    Lower instrument finish panel retainer
    Instrument panel brace assemblies
    Windshield wiper relay assembly and
    Floor shift parking lock cable assembly
    Console box duct
    Rear air ducts

  2. Reassemble the dash components in the reverse of removal.
  3. Install or connect the following:
    NOTE
    Lubricate O-rings with compressor oil



    Heater core hoses
    A/C suction and pressure hoses, attach with bolt and plate



    Negative battery cable

  4. Refill the cooling system to the correct level.
  5. Evacuate and recharge A/C system
  6. Start the engine and check for leaks.

  1. Disconnect the negative battery cable.
  2. Drain the cooling system into a clean container for reuse.
  3. Disconnect the heater hoses from the heater core.
  4. At the driver-s side, remove the lower instrument panel.
  5. Remove the left hand instrument lower panel.
  6. At the heater/air conditioning housing, disengage the 3 heater protector-to-heater/air conditioning housing clips and remove the heater protector.
  7. Remove the 3 heater core pipe clamp screws and the clamps.
  8. Remove the 2 heater core pipe clamp screws and the clamps; then, disconnect the pipes from the heater core.
  9. Remove the heater core.

    Click image to see an enlarged view

    Fig. Exploded view of the instrument panel, heater/air conditioning housing and related components-Solara



    Click image to see an enlarged view

    Fig. Exploded view of the heater/air conditioning housing, heater core, evaporator core and related components-Solara



    Click image to see an enlarged view

    Fig. View of the heater core-Solara


To install:

  1. Install the heater core.
  2. Connect the pipes to the heater core and install the heater core pipe clamp and the 2 clamp screws.
  3. Install the heater core pipe clamps and the 3 clamp screws.
  4. At the heater/air conditioning housing, install the heater protector and engage the 3 heater protector-to-heater/air conditioning housing clips.
  5. Install the left hand instrument lower panel.
  6. At the driver-s side, install the lower instrument panel.
  7. Connect the negative battery cable.
  8. Connect the heater hoses to the heater core.
  9. Refill the cooling system to the correct level.



-----------------

For more car related problem troubleshooting:---

This are the sections, you can go through and click the link to read its troubleshooting.

---------

The car will not start?

http://schematicsdiagram.blogspot.com/2011/06/car-will-not-start.html

-----------------

Car will not crank?

http://schematicsdiagram.blogspot.com/2011/06/car-will-not-crank.html

-----------

Car has no spark?

http://schematicsdiagram.blogspot.com/2011/06/car-has-no-spark.html

-------------

How to troubleshoot car battery?

http://schematicsdiagram.blogspot.com/2011/06/how-to-troubleshoot-car-battery.html

-----------------

How to test starter solenoid?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-starter-solenoid.html

--------------------

How to test cars starter?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-cars-starter.html

How to replace starter in car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-starter-in-car.html

-----------

car will turn over but will not start?

http://technoanswers.blogspot.com/2011/05/car-will-turn-over-but-will-not-start.html

-----------------

The Brake Indicator Light Stays On dash of car?

http://schematicsdiagram.blogspot.com/2011/06/brake-indicator-light-stays-on-dash-of.html

The ABS and Traction Control Lights stays ON dash of car?

http://schematicsdiagram.blogspot.com/2011/06/abs-and-traction-control-lights-stays.html

Check Engine Light On car?

http://schematicsdiagram.blogspot.com/2011/06/check-engine-light-on-car.html

-------------------------

How to replace Interior Lights on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-interior-lights-on-car.html

Car lights not working, even after replacing the bulb/lamp?

Click this link below:--

http://schematicsdiagram.blogspot.com/2011/06/car-lights-not-working-even-after.html

---------------

How to replace head lights on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-head-lights-on-car.html

--------------------

How to replace Parking, turn, and Brake Lights on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-parking-turn-and-brake.html
How to remove the door panel on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-remove-door-panel-on-car.html

How to replace power window motor in car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-replace-power-window-motor-in.html

How to test relays on car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-test-relays-on-car.html

-----------------------------

How to troubleshoot Engine Misfires?

http://schematicsdiagram.blogspot.com/2011/06/how-to-troubleshoot-engine-misfires.html

------------

The spark plug firing order for car?

http://schematicsdiagram.blogspot.com/2011/06/spark-plug-firing-order-for-car.html

------------------------

Where is the Thermostat located in car?

http://schematicsdiagram.blogspot.com/2011/06/where-is-thermostat-located-in-car.html

How to recharge AC on Auto/Truck/car?

http://schematicsdiagram.blogspot.com/2011/06/how-to-recharge-ac-on-autotruckcar.html

-------------------

How to trouble shoot speedometer?

http://schematicsdiagram.blogspot.com/2011/06/speedometer-not-working.html

To Order car parts online:--To get heavy discount on car parts .Click this link below:----

http://technoanswers.blogspot.com/2011/05/from-where-to-order-car-parts-online.html

How to Replace Coil Springs?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-coil-springs.html

How to Replace an Oil Pan Gasket?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-oil-pan-gasket.html

How to Replace a Fuel Injector

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fuel-injector.html

How to Replace a C.O.P. Type Ignition Coil?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-cop-type-ignition-coil.html

How to Replace a Fuel Pressure Regulator?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fuel-pressure-regulator.html

How to Replace a Fuel Pump?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fuel-pump.html

How to Replace a Rear Lift Gate Locking Mechanism?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-lift-gate-locking.html

How to Clean a Fuel System

http://schematicsdiagram.blogspot.com/2011/07/how-to-clean-fuel-system.html

How to Replace an Ignition Coil

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-ignition-coil.html

How to Replace a Windshield

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield.html

How to Replace a Mass Air Flow Sensor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-mass-air-flow-sensor.html

How to Replace a Rear Distance Sensor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-distance-sensor.html

How to Replace a Muffler

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-muffler.html

How to Replace an Engine

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-engine.html

How to Replace an Intake Manifold Gasket

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-intake-manifold-gasket.html

How to Replace an Oil Pump

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-oil-pump.html

How to Lubricate a Brake Pedal Linkage ?

http://schematicsdiagram.blogspot.com/2011/07/how-to-lubricate-brake-pedal-linkage.html

How to Replace a Windshield Wiper Motor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield-wiper-motor.html

How to Replace a Distributor Cap

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-distributor-cap.html

How to Replace a Door Weather Stripping

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-door-weather-stripping.html

How to Replace a Freeze Plug

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-freeze-plug.html

How to Replace a Head Gasket

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-head-gasket.html

How to Replace a Heater Core

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-heater-core.html

How to Replace Spark Plugs?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-spark-plugs.html

How to Replace a Rear Axle Bearing?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-axle-bearing.html

How to Replace a Front Bumper Cover

http://technoanswers.blogspot.com/2011/07/how-to-replace-front-bumper-cover.html

How to Replace a Manual Transmission

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-manual-transmission.html

How to Replace a Headlight Bulb

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-headlight-bulb.html

How to Replace a Headlight Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-headlight-switch.html

How to Replace Windshield Wiper Blades

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield-wiper-blades.html

How to Replace a Cooling Fan

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-cooling-fan.html

How to Replace a Catalytic Converter

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-catalytic-converter.html

How to Replace an Engine Mount

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-engine-mount.html

How to Replace a Fog Light Assembly

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fog-light-assembly.html

How to Change Engine Oil and Filter

http://schematicsdiagram.blogspot.com/2011/07/how-to-change-engine-oil-and-filter.html

How to Replace a Power Seat Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-seat-switch.html

How to Replace a Rear Main Seal

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-main-seal.html

How to Repair a Defroster Grid

http://schematicsdiagram.blogspot.com/2011/07/how-to-repair-defroster-grid.html

How to Replace an AWD Transfer Case

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-awd-transfer-case.html

How to Replace a Plastic License Plate Bracket?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-plastic-license-plate.html

How to Replace a Power Seat Motor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-seat-motor.html

How to Replace Power Steering Fluid

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-steering-fluid.html

How to Replace a Power Window Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-window-switch.html

How to Replace a Quarter Glass Panel?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-quarter-glass-panel.html

How to Pressure Test a Radiator and Cap

http://schematicsdiagram.blogspot.com/2011/07/how-to-pressure-test-radiator-and-cap.html

How to Replace a Radiator

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-radiator.html

How to Repair a Hood.

http://schematicsdiagram.blogspot.com/2011/07/how-to-repair-hood.html

How to Replace an Energy Absorber

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-energy-absorber.html

How to Replace Heater Core Hoses

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-heater-core-hoses.html

How to Replace a Thermostat.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-thermostat.html

How to Rotate Tires.

http://schematicsdiagram.blogspot.com/2011/07/how-to-rotate-tires.html

How to Replace Wheel Lug Nuts

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-wheel-lug-nuts.html

How to Replace a Tire Valve Stem

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-tire-valve-stem.html

How to Change a Flat Tire

http://schematicsdiagram.blogspot.com/2011/07/how-to-change-flat-tire.html

How to Replace Leaf Springs

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-leaf-springs.html

How to Replace a Heater Control Valve

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-heater-control-valve.html

How to Replace Transmission Cooler Lines

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-transmission-cooler.html

How to Replace an Ignition Control Unit

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-ignition-control-unit.html

How to Replace a Brake Hose

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-brake-hose.html

How to Replace a Transfer Case Rear Output Seal

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-transfer-case-rear.html

How to Replace a Seat Belt and Seatbelt Retractor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-seat-belt-and-seatbelt.html

How to Replace a Power Steering Rack

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-power-steering-rack.html

How to Bleed Brakes with a Tool

http://schematicsdiagram.blogspot.com/2011/07/how-to-bleed-brakes-with-tool.html

How to Replace a Tail Light Bulb

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-tail-light-bulb.html

How to Check Automatic Transmission Fluid Level

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-automatic-transmission.html

How to Change Automatic Transmission Fluid and Filter

http://schematicsdiagram.blogspot.com/2011/07/how-to-change-automatic-transmission.html

How to Replace Vacuum Hoses

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-vacuum-hoses.html

How to Replace an Air Intake Boot

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-air-intake-boot.html

How to Replace a Valve Cover Gasket

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-valve-cover-gasket.html

How to Replace a Water Pump

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html

How to Replace a Windshield Wiper Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-windshield-wiper-switch.html

How to Replace Window Run Channel Seals

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-run-channel-seals.html

How to Replace a Window Regulator

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-regulator.html

How to Balance a Tire and Wheel

http://schematicsdiagram.blogspot.com/2011/07/how-to-balance-tire-and-wheel.html

How to Replace a Window Motor

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-window-motor.html

How to Adjust a Hood Release Latch?

http://schematicsdiagram.blogspot.com/2011/07/how-to-adjust-hood-release-latch.html

How to Replace a Radiator Support

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-radiator-support.html

How to Replace a Rear Pinion Seal.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-pinion-seal.html

How to Replace Battery Cables

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-battery-cables.html

How to Replace a Proportioning Valve

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-proportioning-valve.html

How to Replace an Upper Radiator Hose

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-upper-radiator-hose.html

How to Replace a Lower Radiator Hose

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-lower-radiator-hose.html

How to Replace a Timing Belt?

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-timing-belt.html

How to Check for Loose or Worn Suspension

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-for-loose-or-worn.html

How to Check for Loose Steering System

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-for-loose-steering-system.html

How to Replace an Oil Pressure Switch (Sensor)

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-oil-pressure-switch.html

How to Replace a Fender Liner or Splash Shield

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-fender-liner-or-splash.html

How to Replace a Hood Insulator

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-hood-insulator.html

How to Replace a Rear Differential.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-rear-differential.html

How to Repair a Hood Hinge

http://schematicsdiagram.blogspot.com/2011/07/how-to-repair-hood-hinge.html

How to Replace a Brake Pedal Return Spring

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-brake-pedal-return.html

How to Replace a Door Shell.

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-door-shell.html

How to Replace a Transfer Case Front Output Seal

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-transfer-case-front.html

How to Replace a Hood Latch/Lock Assembly

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-hood-latchlock-assembly.html

How to Replace a Lift Gate Strut

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-lift-gate-strut.html

How to Replace Mud Flaps (Mud Guards)

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-mud-flaps.html

How to Check Differential Oil Leaks and Replace Oil.

http://schematicsdiagram.blogspot.com/2011/07/how-to-check-differential-oil-leaks-and.html

How to Replace a Mirror

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-mirror.html

How to Replace a Transfer Case Shift Linkage

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-transfer-case-shift.html

How to Replace a Transmission Mount

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-transmission-mount.html

How to Replace a U-Joint

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-u-joint.html

How to Replace a Washer Tank

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-washer-tank.html

How to Replace an A/C Line or Hose

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-ac-line-or-hose.html

How to Replace a Heater and A/C Blower Motor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-heater-and-ac-blower.html

How to Replace an ABS Control Unit

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-abs-control-unit.html

How to Perform a Brake Adjustment

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-brake-adjustment.html

How to Replace an Alternator Belt

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-alternator-belt.html

How to Replace an Emblem

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-emblem.html

How to Replace an Exhaust Manifold Gasket

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-exhaust-manifold-gasket.html

How to Replace a Tail Pipe

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tail-pipe.html

How to Replace Shock Absorbers

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-shock-absorbers.html

How to Replace a Strut Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-strut-assembly.html

How to Replace a Driveshaft

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-driveshaft.html

How to Replace a Wheel Cylinder

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-wheel-cylinder.html

How to Replace a Hood

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-hood.html

How to Replace a Brake Disc (Rotor)

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-brake-disc-rotor.html

How to Replace a Metal License Plate Bracket

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-metal-license-plate.html

How to Replace a Power Steering Pump

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-power-steering-pump.html

How to Perform a Basic Engine Tune-Up

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-basic-engine-tune-up.html

How to Perform a Basic Engine Tune Up-Oil Change

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-basic-engine-tune-up-oil.html

How to Perform a Basic Engine Tune Up-Spark Plug and Wire Change

http://schematicsdiagram.blogspot.com/2011/08/how-to-perform-basic-engine-tune-up_01.html

How to Replace a Distributor Cap and Rotor ?

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-distributor-cap-and.html

How to Repair a Valance

http://schematicsdiagram.blogspot.com/2011/08/how-to-repair-valance.html

How to Replace a Turn Signal Switch

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-turn-signal-switch.html

How to Replace a Plastic Bumper Cover

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-plastic-bumper-cover.html

How to Replace a Parking Brake Cable

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-parking-brake-cable.html

How to Replace Windshield Wiper Blade Refills

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-windshield-wiper-blade.html

How to Replace a Corner Light

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-corner-light.html

How to Replace a Bumper Bracket or Side Support

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-bumper-bracket-or-side.html

How to Replace a Washer Pump.

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-washer-pump.html

How to Replace a Grille

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-grille.html

How to Replace a Locking Hub

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-locking-hub.html

How to Replace a Fender

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fender.html

How to Replace a Power Steering Hose

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-power-steering-hose.html

How to Replace a Tailgate

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tailgate.html

How to Replace a Soft Top

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-soft-top.html

How to Replace a Carburetor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-carburetor.html

­

How to Replace a Bumper Trim

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-bumper-trim.html

How to Replace Trunk Strut

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-trunk-strut.html

How to Replace a Front End Cover

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-front-end-cover.html

How to Replace a Front Pipe

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-front-pipe.html

How to Replace an Antenna Mast

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-antenna-mast.html

How to Replace a Side Marker Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-side-marker-light.html

How to Install a Carpet on car?

http://schematicsdiagram.blogspot.com/2011/08/how-to-install-carpet-on-car.html

How to Replace a Spoiler

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-spoiler.html

How to Replace a Mirror Glass on car?

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-mirror-glass-on-car.html

How to Replace a Step Bumper?

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-step-bumper.html

How to Replace a Door Lock

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-door-lock.html

How to Replace a Throttle Body

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-throttle-body.html

How to Replace a Throttle Position Sensor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-throttle-position-sensor.html

How to Replace a Grille Insert

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-grille-insert.html

How to Replace a Fan Shroud Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fan-shroud-assembly.html

How to Replace an Engine Splash Shield

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-engine-splash-shield.html

How to Replace a Turn Signal Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-turn-signal-light.html

How to Replace a Headlight Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight-assembly.html

How to Replace a Park Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-park-light-assembly.html

How to Replace an Expansion Tank

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-expansion-tank.html

How to Replace an Exhaust System

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-exhaust-system.html

How to Replace a Fender Trim

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fender-trim.html

How to Replace a Headlight Door

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight-door.html

How to Replace a Fan Shroud

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fan-shroud.html

How to Replace a Harmonic Balancer

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-harmonic-balancer.html

How to Replace a Header Panel

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-header-panel.html

How to Replace a Fuel Tank

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fuel-tank.html

How to Replace a Fuel Tank Cap

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fuel-tank-cap.html

How to Replace a Distributor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-distributor.html

How to Replace an EGR Valve

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-egr-valve.html

How to Replace an Oxygen Sensor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-oxygen-sensor.html

How to Replace an Ignition Wire Set

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-ignition-wire-set.html

How to Replace a Tail Light

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tail-light.html

How to Replace a Door Handle

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-door-handle_18.html

How to Replace a Hood Strut

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-hood-strut.html

How to Replace Tail Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tail-light-assembly.html

How to Replace a Front Bumper

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-front-bumper.html

How to Replace a Fuel Pump Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-fuel-pump-assembly.html

How to Replace an Axle Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-axle-assembly.html

How to Replace a Tailgate Handle

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-tailgate-handle.html

How to Replace a Wheel Hub Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-wheel-hub-assembly.html

How to Replace a Control Arm

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-control-arm.html

How to Replace a Window Regulator with Motor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-window-regulator-with.html

How to Replace a Headlight

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight.html

How to Check the Brake Fluid Level

http://schematicsdiagram.blogspot.com/2011/08/how-to-check-brake-fluid-level.html

How to Replace a Parking Brake Switch

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-parking-brake-switch.html

How to Replace a Blower Motor Resistor

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-blower-motor-resistor.html

How to replace frost plug on car?

http://howtobyme.blogspot.com/2011/08/how-to-replace-frost-plug-on-car.html

Horn stopped working?

http://howtobyme.blogspot.com/2011/08/horn-stopped-working.html

How to clean egr valve on Isuzu Amigo?

http://howtobyme.blogspot.com/2011/08/how-to-clean-egr-valve-on-isuzu-amigo.html

Cruise control stopped working?

http://howtobyme.blogspot.com/2011/08/cruise-control-stopped-working.html

Car is stuck in park and the shift will not move?

http://howtobyme.blogspot.com/2011/08/car-is-stuck-in-park-and-shift-will-not.html

How to change the outer door weather strip?

http://howtobyme.blogspot.com/2011/08/how-to-change-outer-door-weather-strip.html

Car slows down when it gets hotter?

http://howtobyme.blogspot.com/2011/08/car-slows-down-when-it-gets-hotter.html

Warning lights on and speedometer died?

http://howtobyme.blogspot.com/2011/08/warning-lights-on-and-speedometer-died.html

Car won't rev past 1900 rpms?

http://howtobyme.blogspot.com/2011/08/car-wont-rev-past-1900-rpms.html