Tuesday, February 7, 2012

How to Add transmission fluid on 2002 Isuzu AXIOM?

Its a simple procedure.
The dealers use a fluid exchange machine that taps into the transmission oil cooler lines to exchange the old fluid for new. A transmission shop or quick lube shop might also be able to do this for you.


If you want to do it yourself:


There is an "overfill" screw (#1 in the illustration below) under the transmission through which fluid must be added to fill the transmission. You will probably have to use a hand pump to push the fluid through the hole so it can fill the transmission pan.

graphic


  1. Remove the transmission overfill screw (1) and fill transmission through overfill screw opening, using DEXRON-III ATF. Note: Add transmission fluid until it flows out over the overfill screw opening.
  2. Let engine idle until a fluid temperature between 32°C (90°F) and 57°C (135°F) is reached.
  3. Add transmission fluid until it flows out over the overfill screw opening, then close the overfill screw (1). Torque: 38 Nm (28 ft. lbs.) Note: To prevent fluid leaks, the overfill screw and oil drain screws gasket must be replaced each time these screws are removed.

Place the car in "Park" and engage the emergency brake.

Let the car idle for 20 minutes so the engine warms up.

This will help.
Thanks.

See the latest solved car problems :-----

Coolant enters in transmission on Toyota Land cruiser?

http://schematicsdiagram.blogspot.com/2012/01/coolant-enters-in-transmission-on.html

Engine stumbles and shuts off in forward gear on Toyota Land Cruiser?

http://schematicsdiagram.blogspot.com/2012/01/engine-stumbles-and-shuts-off-in.html

Transmission problem?

Car engine Overheats and transmission starts slipping?


Manual Transmission Clutch System Failures?

                                       

Automatic transmission will not go into high gear?

                         

Transmission fluid gets into radiator?


HOW TO REPLACE A MANUAL TRANSMISSION

HOW TO REPLACE TRANSMISSION COOLER LINES

HOW TO CHECK AUTOMATIC TRANSMISSION FLUID LEVEL


HOW TO CHANGE AUTOMATIC TRANSMISSION FLUID AND FILTER


HOW TO REPLACE A TRANSMISSION MOUNT

How to check Transmission fluid on 1996 Chevrolet Camaro?


Transmission fault light on car dash?

Car makes noise when clutch is pressed gently?

Filled T-IV fluid instead of WS transmission fluid?

Manual transmission very hard to shift from one gear to another?

Bell housing and transmission will not come apart on 1996 Toyota Tacoma?

Transmission shifting problem on Toyota Land cruiser?

http://schematicsdiagram.blogspot.com/2012/01/transmission-shifting-problem-on-toyota.html





max